Engineering:Rumford fireplace
The Rumford fireplace is a tall, shallow fireplace designed by Sir Benjamin Thompson, Count Rumford, an Anglo-American physicist best known for his investigations of heat. Its shallow, angled sides are designed to reflect heat into the room, and its streamlined throat minimizes turbulence, thereby carrying away smoke with little loss of heated room air.
History
Rumford appears to have first developed an interest in smoking fireplaces following problems encountered following 1794 renovations of the Palmerston family's house in Hannover Square, Rumford being at the time, in intimate correspondence with Lady Palmerston. Around the end of 1795 Rumford experimented with various designs, his first practical installation being at the Board of Trade in Whitehall. Rumford later installed such fireplaces not only at the Palmerston house, but throughout those of the aristocracy of England.[1]
His designs made the fireplaces smaller and shallower with widely angled covings so they would radiate better. And he streamlined the throat, or in his words "rounded off the breast" so as to "remove those local hindrances which forcibly prevent the smoke from following its natural tendency to go up the chimney..."
Rumford wrote two papers[2][3] detailing his improvements on fireplaces in 1796 and 1798. He was well known and widely read in his lifetime and almost immediately in the 1790s his "Rumford fireplace" became state-of-the-art worldwide. Subsequent testing of Rumford's designs has shown that their efficiency would qualify them as clean-burning stoves.[4]
Principle of action
The Rumford fireplace created a sensation in London when he introduced the idea of restricting the chimney opening to increase the updraft. He and his workers changed fireplaces by inserting bricks into the hearth to make the side walls angled, and they added a choke to the chimney to create a circulation of air inside the chimney. In the unmodified chimney, smoke rises up the chimney propelled only by buoyancy -- the heated gases from the fireplace being lighter than the surrounding air. This is especially ineffective when the fire is first lit, and the temperature and density of the smoke are closer to the ambient air. Thanks to the discontinuity produced by Rumford's brick "smoke shelf", the flow of smoke gases up the chimney became detached from the outside wall at the lip of the shelf. This set up a counter-circulation of outside air which flowed down the backside of the chimney, while a mixture of outside air and smoke flowed up the opposite side. The circulation inside the chimney, and above the smoke shelf, created a dynamic pressure in which the smoke gases were driven up one side of the chimney and cold air was pulled down the other. The air mixed with the rising smoke and increased the combined flow rising up the flue. It produced a circulating air-smoke flow, driving the smoke up into the chimney rather than lingering and often choking the residents. Many fashionable London houses were modified to his instructions and became smoke-free as well as more efficient. Thompson became a celebrity when news of his success became widespread. In an age when fires were the principal source of heat, this simple alteration in the design of fireplaces was copied widely.
Usage
Rumford fireplaces were common from 1796, when Count Rumford first wrote about them, until about 1850. Jefferson had them built at Monticello, and Thoreau listed them among the modern conveniences that everyone took for granted. There are still many original Rumford fireplaces, often buried behind newer renovations. He also invented a cast iron stove, also known as the Rumford stove, which competed successfully with the famous Franklin stove. Both devices gave much more control over the air flow into the fire, and were much more efficient users of fuel. Such stoves were expensive, but saved so much fuel as to justify the cost of installation very quickly. They in turn inspired the development of the kitchen range, also made in cast iron, which gave yet more control of the fire and also was used directly for cooking purposes.
References
- ↑ James, Frank A. J. L. (24 Aug 2023). "When Ben met Mary: The Letters of Benjamin Thompson, Reichsgraf von Rumford, to Mary Temple, Viscountess Palmerston, 1793–1804". Ambix 70 (3): 207-328. doi:10.1080/00026980.2023.2234717. https://www.tandfonline.com/doi/full/10.1080/00026980.2023.2234717?src=. Retrieved 3 October 2023.
- ↑ The Collected Works of Count Rumford; Vol. 2; Sanborn Brown, ed.; Harvard Univ. Press; 1969
- ↑ "Chimney Fireplaces Advertisement". http://www.rumford.com/chimneyfireplacesa.html.
- ↑ Ianto Evans; Linda Smiley; Michael G. Smith; Michael Smith (1 June 2002). The Hand-Sculpted House: A Philosophical and Practical Guide to Building a Cob Cottage. Chelsea Green Publishing. pp. 208–. ISBN 978-1-890132-34-7. https://books.google.com/books?id=tGEmmolyeSUC&pg=PA208. Retrieved 22 February 2013.
Bibliography
- G. I. Brown, Count Rumford: The Extraordinary Life of a Scientific Genius, Sutton Publishing (1999).
External links
 |  |
