Engineering:Boeing X-20 Dyna-Soar
The Boeing X-20 Dyna-Soar ("Dynamic Soarer") was a United States Air Force (USAF) program to develop a spaceplane that could be used for a variety of military missions, including aerial reconnaissance, bombing, space rescue, satellite maintenance, and as a space interceptor to sabotage enemy satellites. The program ran from 24 October 1957 to 10 December 1963, cost US$660 million ($NaN in current dollars), and was cancelled just after spacecraft construction had begun.
Other spacecraft under development at the time, such as Mercury or Vostok, were space capsules with ballistic re-entry profiles that ended in a landing under a parachute. Dyna-Soar was more like an aircraft. It could travel to distant targets at the speed of an intercontinental ballistic missile, was designed to glide to Earth like an aircraft under control of a pilot, and could land at an airfield. Dyna-Soar could also reach Earth orbit, like conventional, manned space capsules.
These characteristics made Dyna-Soar a far more advanced concept than other human spaceflight missions of the period. Research into a spaceplane was realized much later in other reusable spacecraft such as the 1981–2011 Space Shuttle and the more recent Boeing X-40 and X-37B spacecraft.
Following World War II, many German scientists were taken to the United States by the Office of Strategic Services's Operation Paperclip, bringing with them detailed knowledge of the Silbervogel project. A similar boost-glide system was pitched to the USAF, resulting in a request for feasibility and design studies. These were carried out by Bell Aircraft Corporation, Boeing, Convair, Douglas, Martin, North American, Republic, and Lockheed, resulting in a number of early 1950s concepts:
- Bomi (bomber missile)
- Hywards (HYpersonic Weapons Research and Development Supporting system)
- The Brass Bell reconnaissance vehicle
- RoBo (Rocket Bomber)
These studies all proposed various rocket-powered vehicles that could travel vast distances by gliding after being boosted to high speed and altitude by a rocket stage.
Lifting re-entry method
The rocket booster would place the vehicle onto a suborbital, but exoatmospheric, trajectory, resulting in a brief spaceflight followed by recontact with the atmosphere. Instead of a full reentry and landing, the vehicle would use the lift from its wings to redirect its glide angle upward, trading horizontal velocity for vertical velocity. In this way, the vehicle would be "bounced" back into space again. This skip-glide method would repeat until the speed was low enough that the pilot of the vehicle would need to pick a landing spot and glide the vehicle to a landing. This use of hypersonic atmospheric lift meant that the vehicle could greatly extend its range over a ballistic trajectory using the same rocket booster.
On either 10 October or 24 October 1957, the ARDC (USAF Air Research and Development Command) headquarters consolidated Hywards, Brass Bell, and Robo studies into the Dyna-Soar project or System 464L, with a three-step abbreviated development plan. The proposal drew together the existing boost-glide proposals into a single vehicle designed to carry out all the bombing and reconnaissance tasks examined by the earlier studies, and would act as successor to the X-15 research program.
The three stages of the Dyna-Soar program were to be a research vehicle (Dyna-Soar I), a reconnaissance vehicle (Dyna-Soar II, previously Brass Bell), and a vehicle that added strategic bombing capability (Dyna-Soar III, previously Robo). The first glide tests for Dyna-Soar I were expected to be carried out in 1963, followed by powered flights, reaching Mach 18, the following year. A robotic glide missile was to be deployed in 1968, with the fully operational weapons system (Dyna-Soar III) expected by 1974.
In March 1958, nine U.S. aerospace companies tendered for the Dyna-Soar contract. Of these, the field was narrowed to proposals from Bell and Boeing. Even though Bell had the advantage of six years' worth of design studies, the contract for the spaceplane was awarded to Boeing in June 1959 (by which time their original design had changed markedly and now closely resembled what Bell had submitted). In late 1961, the Titan III was chosen as the launch vehicle. The Dyna-Soar was to be launched from Cape Canaveral Air Force Station, Florida.
The overall design of the X-20 Dyna-Soar was outlined in March 1960. It had a low-wing delta shape, with winglets for control rather than a more conventional tail. The framework of the craft was to be made from the René 41 super alloy, as were the upper surface panels. The bottom surface was to be made from molybdenum sheets placed over insulated René 41, while the nose-cone was to be made from graphite with zirconia rods.
Due to changing requirements, several versions of the Dyna-Soar were considered, all sharing the same basic shape and layout. A single pilot sat at the front, with an equipment bay situated behind. This bay contained data-collection equipment, weapons, reconnaissance equipment, or a four-person mid-deck in the case of the X-20X shuttle space vehicle. A Transtage upper rocket stage attached to the aft end of the craft would allow orbital maneuvers and a launch abort capability before being jettisoned before descent into the atmosphere. While falling through the atmosphere an opaque heat shield made from a refractory metal would protect the window at the front of the craft. This heat shield would then be jettisoned after aerobraking so the pilot could see, and safely land.
A drawing in the Space/Aeronautics magazine from before the project's cancellation depicts the craft skimming the surface of the atmosphere to change its orbital inclination. It would then fire its rocket to resume orbit. This would be a unique ability for a spacecraft, as the laws of celestial mechanics mean it requires an enormous expenditure of energy to change an orbital inclination once established. The Dyna-Soar was projected to be able to use this capability to rendezvous with satellites even if the target conducted evasive maneuvers. Acceleration forces on the pilot would be severe in such a maneuver.
Unlike the later Space Shuttle, Dyna-Soar did not have wheels on its tricycle undercarriage, as rubber tires would have caught fire during re-entry. Instead Goodyear developed retractable wire-brush skids made of the same René 41 alloy as the airframe.
In April 1960, seven astronauts were secretly chosen for the Dyna-Soar program:
- Neil Armstrong (1930–2012; NASA) 1960–1962
- William H. "Bill" Dana (1930–2014; NASA) 1960–1962
- Henry C. Gordon (1925–1996; Air Force) 1960–1963
- Pete Knight (1929–2004; Air Force) 1960–1963
- Russell L. Rogers (1928–1967; Air Force) 1960–1963
- Milt Thompson (1926–1993; NASA) 1960–1963
- James W. Wood (1924–1990; Air Force) 1960–1963
Neil Armstrong and Bill Dana left the program in mid-1962. On 19 September 1962, Albert Crews was added to the Dyna-Soar program and the names of the six remaining Dyna-Soar astronauts were announced to the public.
By the end of 1962, Dyna-Soar had been designated X-20, the booster (to be used in the Dyna Soar I drop-tests) successfully fired, and the USAF had held an unveiling ceremony for the X-20 in Las Vegas.
The Minneapolis-Honeywell Regulator Company (later the Honeywell Corporation) completed flight tests on an inertia guidance sub-system for the X-20 project at Eglin Air Force Base, Florida, utilizing an NF-101B Voodoo by August 1963.
Boeing B-52C-40-BO Stratofortress 53-0399 was assigned to the program for air-dropping the X-20, similar to the X-15 launch profile. When the X-20 was cancelled, it was used for other air-drop tests including that of the B-1A escape capsule.
Besides the funding issues that often accompany research efforts, the Dyna-Soar program suffered from two major problems: uncertainty over the booster to be used to send the craft into orbit, and a lack of a clear goal for the project.
Many different boosters were proposed to launch Dyna-Soar into orbit. The original USAF proposal suggested LOX/JP-4, fluorine-ammonia, fluorine-hydrazine, or RMI (X-15) engines. Boeing, the principal contractor, favored an Atlas-Centaur combination. Eventually (Nov 1959:18) the Air Force stipulated a Titan, as suggested by failed competitor Martin, but the Titan I was not powerful enough to launch the five-ton X-20 into orbit.
The Titan II and Titan III boosters could launch Dyna-Soar into Earth orbit, as could the Saturn C-1 (later renamed the Saturn I), and all were proposed with various upper-stage and booster combinations. While the new Titan IIIC was eventually chosen (Dec 1961:19) to send Dyna-Soar into space, the vacillations over the launch system delayed the project as it complicated planning.
The original intention for Dyna-Soar, outlined in the Weapons System 464L proposal, called for a project combining aeronautical research with weapons system development. Many questioned whether the USAF should have a crewed space program, when that was the primary domain of NASA. It was frequently emphasized by the U.S. Air Force that, unlike the NASA programs, Dyna-Soar allowed for controlled re-entry, and this was where the main effort in the X-20 program was placed. On January 19, 1963, the Secretary of Defense, Robert McNamara, directed the U.S. Air Force to undertake a study to determine whether Gemini or Dyna-Soar was the more feasible approach to a space-based weapon system. In the middle of March 1963, after receiving the study, Secretary McNamara "stated that the Air Force had been placing too much emphasis on controlled re-entry when it did not have any real objectives for orbital flight". This was seen as a reversal of the Secretary's earlier position on the Dyna-Soar program. Dyna-Soar was also an expensive program that would not launch a crewed mission until the mid-1960s at the earliest. This high cost and questionable utility made it difficult for the U.S. Air Force to justify the program. Eventually, the X-20 Dyna-Soar program was canceled on December 10, 1963.
On the day that X-20 was canceled, the U.S. Air Force announced another program, the Manned Orbiting Laboratory, a spin-off of Gemini. This program was also eventually canceled. Another black program, ISINGLASS, which was to be air-launched from a B-52 bomber, was evaluated and some engine work done, but it too was eventually cancelled.
Despite cancellation of the X-20, the affiliated research on spaceplanes influenced the much larger Space Shuttle. The final design also used delta wings for controlled landings. The later, and much smaller Soviet BOR-4 was closer in design philosophy to the Dyna-Soar, while NASA's Martin X-23 PRIME and Martin Marietta X-24A/HL-10 research aircraft also explored aspects of sub-orbital and space flight. The ESA proposed Hermes crewed space craft took the design and expanded its scale.
Specifications (as designed)
- Crew: One pilot
- Length: 35.34 ft (10.77 m)
- Wingspan: 20.8 ft (6.3 m)
- Height: 8.5 ft (2.6 m)
- Wing area: 345 sq ft (32.1 m2)
- Empty weight: 10,395 lb (4,715 kg)
- Max takeoff weight: 11,387 lb (5,165 kg)
- Powerplant: 2 × AJ10-138 rocket engine, 8,000 lbf (36 kN) thrust each
- Maximum speed: 17,500 mph (28,200 km/h, 15,200 kn)
- Range: 25,000 mi (41,000 km, 22,000 nmi)
- Service ceiling: 530,000 ft (160,000 m)
- Rate of climb: 100,000 ft/min (510 m/s)
- Wing loading: 33 lb/sq ft (160 kg/m2)
- The 1959 Twilight Zone season 1 episode titled And When the Sky Was Opened made reference to a spacecraft called the X20 which had a similar profile but could carry a crew of three.
- In 1962, the fifth book in Donald A. Wollheim's Mike Mars series, Mike Mars flies the Dyna-Soar, had the title character fly an emergency rescue mission in the Dyna-Soar.
- John Berryman's 1963 short story The Trouble with Telstar featured a Dyna-Soar being used to intercept communications satellites for repair.
- The 1969 Hollywood film drama Marooned featured a rescue craft modeled somewhat after the Dyna-Soar (called the X-RV for eXperimental Rescue Vehicle) being hurriedly deployed to rescue astronauts aboard a crippled Apollo command capsule. This was lampooned in Mad Magazine as the XRT, the Experimental Rescue Thing.
- Manned Orbital Laboratory
Aircraft of comparable role, configuration and era
- ASSET – a subscale reentry test vehicle designed to verify the superalloy heatshield of the DynaSoar.
- Mikoyan-Gurevich MiG-105
- North American X-15
- Goebel, Greg. "The X-15, Dyna-Soar, & The Lifting Bodies – [1.2 The USAF and DYNA-SOAR"]. Vectors by Greg Goebel. Archived from the original on January 19, 2015. https://web.archive.org/web/20150119075446/http://www.vectorsite.net/tashutl_c01.html#m2. Retrieved January 16, 2015.
- Federal Reserve Bank of Minneapolis. "Consumer Price Index (estimate) 1800–". https://www.minneapolisfed.org/about-us/monetary-policy/inflation-calculator/consumer-price-index-1800-.
- "History: X-20 Dyna-Soar Space Vehicle." Boeing. Retrieved: September 24, 2010.
- Yenne 1985, p. 136
- Bilstein, Roger E. (2003). Testing aircraft, exploring space : an illustrated history of NACA and NASA. Baltimore: Johns Hopkins Univ. Press. p. 90. ISBN 0801871581. https://books.google.com/books?id=dYOh1f0EdZUC&pg=PA90.
- Dornberger 1956, pp. 19–37.
- "Bomi". Archived from the original on June 6, 2017. https://web.archive.org/web/20170606114831/http://astronautix.com/b/bomi.html.
- MX-2276 "Archived copy". Archived from the original on February 10, 2015. https://web.archive.org/web/20150210112513/http://www.dtic.mil/dtic/tr/fulltext/u2/073754.pdf. Retrieved 2015-02-10.
- "Hywards". Encyclopedia Astronautica. Archived from the original on December 28, 2016. https://web.archive.org/web/20161228084416/http://astronautix.com/h/hywards.html. Retrieved 2015-02-10.
- "Brass Bell". Archived from the original on July 7, 2017. https://web.archive.org/web/20170707061919/http://www.astronautix.com/b/brassbell.html.
- "Archived copy". Archived from the original on February 10, 2015. https://web.archive.org/web/20150210111504/http://www.dtic.mil/dtic/tr/fulltext/u2/136057.pdf. Retrieved 2015-02-10.
- Neufeld 1995, pp. 19, 33, 55.
- "Robo". Archived from the original on June 6, 2017. https://web.archive.org/web/20170606114253/http://astronautix.com/r/robo.html.
- Duffy 2004, p. 124.
- Launius, Roger D.; Jenkins, Dennis R. (2012). Coming home : reentry and recovery from space. Washington, DC: National Aeronautics and Space Administration. p. 170. ISBN 0160910641. https://books.google.com/books?id=7k1sawDR-kEC&pg=PA170.
- History of the X-20A Dyna-Soar, Clarence J. Geiger, Sep 1963 www.dtic.mil/cgi-bin/GetTRDoc?AD=ADA951933
- Godwin 2003, p. 38
- Godwin 2003, p. 65
- Godwin 2003, p. 286
- Godwin 2003, p. 186
- Launius, Roger D.; Jenkins, Dennis R. (2012). Coming home : reentry and recovery from space. Washington, DC: National Aeronautics and Space Administration. p. 178. ISBN 978-0-16-091064-7. https://books.google.com/books?id=7k1sawDR-kEC&pg=PA178.
- Heppenheimer, T.A. (September 2007). Facing the Heat Barrier: A History of Hypersonics. Washington, DC: National Aeronautics and Space Administration – History Division. p. 150. ISBN 978-1493692569. https://history.nasa.gov/sp4232-part2.pdf. Retrieved January 16, 2015.
- Pelt, Michel van (2012). Rocketing into the future : the history and technology of rocket planes. New York: Springer. p. 269. ISBN 978-1461431992. https://books.google.com/books?id=4M9i-FXVKckC&pg=PA269.
- Peebles, Curtis (1997). High frontier : the U.S. Air Force and the Military Space Program (Air Force 50th anniversary commemorative ed.). Washington, DC: Air Force History and Museums Program. p. 19. ISBN 0160489458. https://books.google.com/books?id=cMgdYypcPc8C&pg=PA19.
- Jenkins, compiled by Dennis R. (2004). X-planes photo scrapbook. North Branch, MN: Specialty Press. p. 95. ISBN 978-1580070768. https://books.google.com/books?id=uD8cBQAAQBAJ&pg=PA95.
- "Fiery Crash of Drone Plane Kills Two, Injures One – Four Firemen Overcome in Wake of Blaze." Playground Daily News (Fort Walton Beach, Florida), Volume 16, Number 271, August 20, 1963, p. 1.
- "1953 USAF Serial Numbers". Archived from the original on July 23, 2011. https://web.archive.org/web/20110723051310/http://www.joebaugher.com/usaf_serials/1953.html.
- Spahr, Greg, "Might have beens",B-52 Stratofortress: Celebrating 60 Remarkable Years, Key Publishing Ltd., Stamford, Lincs., UK, 2014, page 38.
- Geiger 1963, pp. 349–405.
- "The U-2's intended successor: Project OXCART, 1956–1968." Central Intelligence Agency,December 31, 1968, p. 49. Retrieved: August 10, 2010.
- Marks, Paul. "Cosmonaut: Soviet space shuttle was safer than NASA's." New Scientist, July 7, 2007. Retrieved: August 28, 2011.
- Jenkins, Dennis R., Tony Landis and Jay Miller. American X-Vehicles: An Inventory—X-1 to X-50. Washington, DC: Monographs in Aerospace History No. 31, SP-2003-4531, June 2003.
- Berryman, John (June 1963). "The Trouble with Telstar". Analog Science Fact & Fiction. Archived from the original on September 24, 2015. https://web.archive.org/web/20150924214025/http://www.gutenberg.org/files/30679/30679-h/30679-h.htm. Retrieved 14 May 2015.
- Caidin, Martin. Wings into Space: The History and Future of Winged Space Flight. New York: Holt, Rinehart and Winston Inc., 1964.
- Dornberger, Walter R. "The Rocket-Propelled Commercial Airliner". Dyna-Soar: Hypersonic Strategic Weapons System, Research Report No 135.. Minneapolis, Minnesota: University of Minnesota, Institute of Technology, 1956.
- Duffy, James P. Target: America, Hitler's Plan to Attack the United States. Santa Barbara, California: Praeger, 2004. ISBN:0-275-96684-4.
- Dyna-Soar: Hypersonic Strategic Weapons System: Structure Description Report. Andrews Air Force Base, Maryland: Air Force Systems Command, 1961, pp. 145–189.
- Geiger, Clarence J. History of the X-20A Dyna-Soar. Vol. 1: AFSC Historical Publications Series 63-50-I, Document ID ASD-TR-63-50-I. Wright Patterson AFB, Ohio: Aeronautical Systems Division Information Office, 1963.
- Godwin, Robert, ed (2003). Dyna-Soar: Hypersonic Strategic Weapons System. Burlington, Ontario, Canada: Apogee Books. ISBN 1-896522-95-5.
- Houchin, Roy. U.S. Hypersonic Research and Development: The Rise and Fall of Dyna-Soar, 1944–1963. London: Routledge, 2006. ISBN:0-415-36281-4.
- Neufeld, Michael J. (1995). The Rocket and the Reich: Peenemünde and the Coming of the Ballistic Missile Era. New York: The Free Press. ISBN 978-0-674-77650-0. https://archive.org/details/isbn_9780029228951.
- Strathy, Charlton G. (1957). Dyna-Soar: Hypersonic Strategic Weapons System: Weapon System 464L Abbreviated Development Plan.
- Yenne, Bill (1985). The Encyclopedia of US Spacecraft. London: Bison Books. ISBN 978-5-551-26650-1.
- Dyna Soar at Encyclopedia Astronautica
- Official United States Air Force film from the 1960 describing the spacecraft.
- Tsien Space Plane 1949 at Encyclopedia Astronautica
- Tsien Space Plane 1978
- Transonic aerodynamic characteristics of the Dyna-Soar glider and Titan 3 launch vehicle configuration with various fin arrangements (PDF format) NASA report – April 1963
- American X-Vehicles: An Inventory X-1 to X-50, SP-2000-4531 – June 2003; NASA online PDF Monograph
- LIFE 22 Feb 1963 article about X-20 and the pilots training to fly it.
https://en.wikipedia.org/wiki/Boeing X-20 Dyna-Soar was the original source. Read more.