Engineering:STS-51-L

Short description: Failed 1986 American crewed spaceflight

STS-51-L

Challenger launches at the start of STS-51-L. 73 seconds later, the shuttle would disintegrate, killing all 7 crew on board.
Names	Space Transportation System-25
Mission type	Satellite deployment
Operator	NASA
Mission duration	6 days, 0 hour 34 minutes (planned) 1 minute 13 seconds (achieved)
Distance travelled	18 mi (29 km)
Orbits completed	Failed to achieve orbit (96 planned)
Spacecraft properties
Spacecraft	Space Shuttle Challenger
Launch mass	2,685,210 lb (1,217,990 kg)
Landing mass	199,704 lb (90,584 kg) (planned)
Payload mass	48,363 lb (21,937 kg)
Crew
Crew size	7
Members	Francis R. "Dick" Scobee Michael J. Smith Ellison S. Onizuka Judith A. Resnik Ronald E. McNair S. Christa McAuliffe Gregory B. Jarvis
Start of mission
Launch date	January 28, 1986, 11:38:00 am EST
Rocket	Space Shuttle Challenger
Launch site	Kennedy Space Center, LC-39B
Contractor	Rockwell International
End of mission
Destroyed	January 28, 1986, 11:39:13 am EST
Landing date	February 3, 1986, 12:12:00 pm EST (planned)
Landing site	Kennedy Space Center, SLF Runway 33 (planned)
Orbital parameters
Reference system	Geocentric orbit (planned)
Regime	Low Earth orbit
Perigee altitude	177 mi (285 km)
Apogee altitude	183 mi (295 km)
Inclination	28.45°
Period	90.40 minutes
Instruments
Comet Halley Active Monitoring Program (CHAMP) Fluid Dynamics Experiment (FDE) Phase Partitioning Experiment (PPE) Shuttle Pointed Autonomous Research Tool for Astronomy (SPARTAN-203) Shuttle Student Involvement Program (SSIP) Teacher in Space Project (TISP)
STS-51-L mission patch Back row: Ellison S. Onizuka, S. Christa McAuliffe, Gregory B. Jarvis, Judith A. Resnik Front row: Michael J. Smith, Francis R. "Dick" Scobee, Ronald E. McNair Space Shuttle program

STS-51-L was the 25th mission of NASA's Space Shuttle program and the final flight of Space Shuttle Challenger.

Planned as the first Teacher in Space Project flight in addition to observing Halley's Comet for six days and performing a routine satellite deployment, the mission never achieved orbit; a structural failure during its ascent phase 73 seconds after launch from Kennedy Space Center Launch Complex 39B on January 28, 1986, killed all seven crew members —Commander Francis R. "Dick" Scobee, Pilot Michael J. Smith, Mission Specialists Ellison S. Onizuka, Judith A. Resnik and Ronald E. McNair, and Payload Specialists Gregory B. Jarvis and S. Christa McAuliffe—and destroyed the orbiter.

Immediately after the disaster, President Ronald Reagan convened the Rogers Commission to determine the cause of the explosion. The failure of an O-ring seal on the starboard Solid Rocket Booster (SRB) was determined to have caused the shuttle to break up in flight. Space Shuttle flights were suspended while the O-rings and other hazards that could have destroyed the vehicle on following missions were addressed. Shuttle missions resumed in September 1988 with STS-26, launched 32 months after the accident.

Planned mission

The tenth mission for Challenger, STS-51-L, was scheduled to deploy the second in a series of Tracking and Data Relay Satellites (TDRS-B), carry out the first flight of the "Shuttle Pointed Autonomous Research Tool for Astronomy" (SPARTAN-203) / Halley's Comet Experiment Deployable in order to observe Halley's Comet, and carry out several lessons from space as part of the Teacher in Space Project and Shuttle Student Involvement Program (SSIP). The flight marked the first American orbital mission to involve in-flight fatalities. It was also the first American human spaceflight mission to launch and fail to reach space; the first such mission in the world had been the Soviet Soyuz 18a mission, in which the two crew members had survived. Gregory Jarvis was originally scheduled to fly on the previous shuttle flight (STS-61-C), but he was reassigned to this flight and replaced by Congressman Clarence W. "Bill" Nelson.

Crew

Position	Astronaut
Commander	Francis R. "Dick" Scobee Would have been second spaceflight
Pilot	Michael J. Smith Would have been first spaceflight
Mission Specialist 1	Ellison S. Onizuka Would have been second spaceflight
Mission Specialist 2	Judith A. Resnik Would have been second spaceflight
Mission Specialist 3	Ronald E. McNair Would have been second spaceflight
Payload Specialist 1	Gregory B. Jarvis Would have been first spaceflight Hughes Space and Communications
Payload Specialist 2	S. Christa McAuliffe Would have been first spaceflight Teacher in Space Project

Backup crew

Position	Astronaut
Payload Specialist 1	L. William Butterworth Would have been first spaceflight Hughes Space and Communications
Payload Specialist 2	Barbara R. Morgan Would have been first spaceflight Teacher in Space Project
Morgan would be selected as a NASA astronaut in 1998 and flew on STS-118 in 2007 as a mission specialist.

Crew seating arrangement

Seat	Launch	Landing	Seats 1–4 are on the Flight Deck. Seats 5–7 are on the Middeck.
S1	Scobee	Scobee
S2	Smith	Smith
S3	Onizuka	McNair
S4	Resnik	Resnik
S5	McNair	Onizuka
S6	Jarvis	Jarvis
S7	McAuliffe	McAuliffe

Although the crew died in the Challenger disaster, their seating assignment chart depicts what would have happened if the mission had been performed as planned.

Ascent failure and disaster

Challenger after the explosion 73 seconds after launch

During the ascent phase, 73 seconds after liftoff, the vehicle experienced a catastrophic structural failure resulting in the loss of crew and vehicle. The Rogers Commission later determined the cause of the accident to have been the failure of the primary and secondary (backup) O-ring seals on Challenger's right Solid Rocket Booster (SRB). The failure of these seals allowed a flamethrower-like flare to impinge upon one of two aft SRB attach struts, which eventually failed, freeing the booster to pivot about its remaining attachment points. The forward part of the booster cylinder struck the external tank inter-tank area, leading to a structural failure of the Space Shuttle external tank (ET) – the core structural component of the entire stack. A rapid burning of liberated propellants ensued. With the structural "backbone" of the stack compromised and breaking up, the SRBs flew off on their own, as did the orbiter, which rapidly disintegrated due to overwhelming aerodynamic forces. The launch had been approved despite a predicted ambient temperature of 27 °F (−3 °C), well below the qualification limit of major components such as the SRBs, which had been certified for use only at temperatures above 39 °F (4 °C). Evidence found in the remnants of the crew cabin showed that several of the emergency Personal Egress Air Packs (PEAPs) carried by the astronauts had been manually activated, suggesting that forces experienced inside the cabin during breakup of the orbiter were not inherently fatal, and that at least three crew members were alive and capable of conscious action for a period following vehicle breakup. "Tracking reported that the vehicle had exploded and impacted the water in an area approximately located at 28.64° north, 80.28° west".

Crew fate

Divers from the USS Preserver located what they believed to be the crew cabin on the ocean floor on March 7, 1986. A dive the following day confirmed that it was the cabin and that the remains of the crew were inside. No official investigation into the Challenger disaster has determined the cause of death of the astronauts; it is almost certain that the disintegration itself did not kill the entire crew as 3 of the 4 Personal Egress Air Packs (PEAPs) that were recovered had been manually activated. This would only be done during an emergency or loss of cabin pressure. PEAPs do not provide a pressurized air flow and would still have resulted in the astronauts losing consciousness within several seconds. There were media reports alleging that NASA had a tape recording of the crew panicking and on-board conversation following the disintegration during the 2 minute 45 second free fall before hitting the sea east of Florida. This was likely fabricated and no recording exists, as the crew may have been unconscious from loss of cabin pressure and the astronauts did not wear individual voice recorders.

Mission objectives

• Deployment of Tracking Data Relay Satellite-B (TDRS-B) with an Inertial Upper Stage (IUS) booster
• Flight of "Shuttle Pointed Autonomous Research Tool for Astronomy" (SPARTAN-203)/Halley's Comet Experiment Deployable
• Fluid Dynamics Experiment (FDE)
• Comet Halley Active Monitoring Program (CHAMP)
• Phase Partitioning Experiment (PPE)
• Three Shuttle Student Involvement Program (SSIP) experiments
• Two lessons for the Teacher in Space Project (TISP)
• (unofficial) Ronald E. McNair was planning to play the saxophone in space for a track on Jean-Michel Jarre's album "Rendez-Vous".

Attempt	Planned	Result	Turnaround	Reason	Decision point	Weather go (%)	Notes
1	1986-01-22, 15:43:00 22 Jan 1986, 3:43:00 pm	Rescheduled	—	Delays in STS-61-C
2	1986-01-23, 15:43:00 23 Jan 1986, 3:43:00 pm	Rescheduled	1 day, 0 hours, 0 minutes	Delays in STS-61-C
3	1986-01-24, 15:43:00 24 Jan 1986, 3:43:00 pm	Scrubbed	1 day, 0 hours, 0 minutes	Weather at transatlantic abort site
4	1986-01-25, 09:37:00 25 Jan 1986, 9:37:00 am	Scrubbed	0 days, 17 hours, 54 minutes	Launch preparation delays
5	1986-01-27, 09:37:00 27 Jan 1986, 9:37:00 am	Scrubbed	2 days, 0 hours, 0 minutes	Equipment failures in orbiter closeout, cross winds at shuttle landing site.
6	1986-01-28, 09:37:00 28 Jan 1986, 9:37:00 am	Delayed	1 day, 0 hours, 0 minutes	Technical issues with fire detection system.
7	1986-01-28, 11:38:00 28 Jan 1986, 11:38:00 am	Loss of vehicle and crew	0 days, 2 hours, 1 minute

Mission insignia

Francis R. "Dick" Scobee asked Kennedy Space Center engineer Ernie Reyes to design the mission patch seen above to represent the mission STS-51-L. In it, Challenger is depicted launching from Florida and soaring into space to carry out a variety of goals. Among the prescribed duties of the five astronauts and two payload specialists (represented by the seven stars of the U.S. flag) was observation and photography of Halley's Comet, backdropped against the U.S. flag in the insignia. Surnames of the crew members encircle the scene, with the payload specialists being recognized below. The surname of the first teacher in space, S. Christa McAuliffe, is followed by a symbolic apple.

See also

• Apollo 1
• STS-51-L mission timeline
• Space Shuttle Columbia disaster
• Space Shuttle program
• Challenger Center for Space Science Education

External links

• "Rogers Comission Report on the Challenger accident". June 6, 1986. https://sma.nasa.gov/SignificantIncidents/assets/rogers_commission_report.pdf. 
• "Sparton 203". https://space.skyrocket.de/doc_sdat/spartan-203.htm#:~:text=Spartan%20203%20(Shuttle%20Pointed%20Autonomous,experiment%20to%20observe%20Halley's%20Comet..