Chemistry:Chloropicrin

From HandWiki
Revision as of 20:23, 5 February 2024 by Importwiki (talk | contribs) (change)
(diff) ← Older revision | Latest revision (diff) | Newer revision → (diff)
Chloropicrin
Chloropicrin.png
Chloropicrin-3D-balls.png
Names
IUPAC name
trichloro(nitro)methane
Other names
Tri-clor, PS, Nitrochloroform, Trichloronitromethane, Nitrotrichloromethane
Identifiers
3D model (JSmol)
1756135
ChEBI
ChEMBL
ChemSpider
EC Number
  • 200-930-9
240197
KEGG
RTECS number
  • PB6300000
UNII
UN number 1580
Properties
CCl3NO2
Molar mass 164.375 g/mol
Appearance colorless liquid
Odor irritating[1]
Density 1.692 g/ml[2]
Melting point −69 °C (−92 °F; 204 K)
Boiling point 112 °C (234 °F; 385 K) (decomposes)
0.2%[1]
Vapor pressure 18 mmHg (20°C) [1]
-75.3·10−6 cm3/mol
Hazards
Main hazards Extremely toxic and irritating to skin, eyes, and lungs.
GHS pictograms GHS05: CorrosiveGHS06: ToxicGHS08: Health hazardGHS09: Environmental hazard
GHS Signal word Danger
H301, H314, H330, H370, H372, H410
P260, P264, P270, P271, P273, P280, P284, P301+310, P301+330+331, P303+361+353, P304+340, P305+351+338, P307+311, P310, P314, P320, P321, P330, P363, P391, P403+233, P405, P501
NFPA 704 (fire diamond)
Flammability code 0: Will not burn. E.g. waterHealth code 4: Very short exposure could cause death or major residual injury. E.g. VX gasReactivity code 3: Capable of detonation or explosive decomposition but requires a strong initiating source, must be heated under confinement before initiation, reacts explosively with water, or will detonate if severely shocked. E.g. hydrogen peroxideSpecial hazards (white): no codeNFPA 704 four-colored diamond
0
4
3
Lethal dose or concentration (LD, LC):
9.7 ppm (mouse, 4 hr)
117 ppm (rat, 20 min)
14.4 ppm (rat, 4 hr)[3]
293 ppm (human, 10 min)
340 ppm (mouse, 1 min)
117 ppm (cat, 20 min)[3]
NIOSH (US health exposure limits):
PEL (Permissible)
 TWA 0.1 ppm (0.7 mg/m3)[1]
REL (Recommended)
 TWA 0.1 ppm (0.7 mg/m3)[1]
IDLH (Immediate danger)
 2 ppm[1]
Except where otherwise noted, data are given for materials in their standard state (at 25 °C [77 °F], 100 kPa).
☑Y verify (what is ☑Y☒N ?)
Infobox references

Chloropicrin, also known as PS (from Port Sunlight[4]) and nitrochloroform, is a chemical compound currently used as a broad-spectrum antimicrobial, fungicide, herbicide, insecticide, and nematicide.[5] It was used as a poison gas in World War I. Its chemical structural formula is Cl3CNO2.

Synthesis

Chloropicrin was discovered in 1848 by Scottish chemist John Stenhouse. He prepared it by the reaction of sodium hypochlorite with picric acid:

HOC6H2(NO2)3 + 11 NaOCl → 3 Cl3CNO2 + 3 Na2CO3 + 3 NaOH + 2 NaCl

Because of the precursor used, Stenhouse named the compound chloropicrin, although the two compounds are structurally dissimilar.

Today, chloropicrin is manufactured by the reaction of nitromethane with sodium hypochlorite:[6]

H3CNO2 + 3 NaOCl → Cl3CNO2 + 3 NaOH

or by the reaction of chloroform with nitric acid:

CHCl3 + HNO3 → CCl3NO2 + H2O

Properties

Chloropicrin's chemical formula is CCl3NO2 and its molecular weight is 164.38 grams/mole.[7] Pure chloropicrin is a colorless liquid, with a boiling point of 112 °C.[7] Chloropicrin is sparingly soluble in water with solubility of 2 g/L at 25 °C.[7] It is volatile, with a vapor pressure of 23.2 millimeters of mercury (mmHg) at 25 °C; the corresponding Henry's law constant is 0.00251 atmosphere-cubic meter per mole.[7] The octanol-water partition coefficient (Kow) of chloropicrin is estimated to be 269.[7] Its soil adsorption coefficient (Koc; normalized to soil organic matter content) is 25 cm3/g.[7]

Use

Chloropicrin was manufactured for use as poison gas in World War I.[8] In agriculture, chloropicrin is injected into soil prior to planting a crop to fumigate soil. Chloropicrin affects a broad spectrum of fungi, microbes, and insects.[9][10] It is commonly used as a stand-alone treatment or in combination / co-formulation with methyl bromide and 1,3-dichloropropene.[10][11] Chloropicrin is used as an indicator and repellent when fumigating residences for insects with sulfuryl fluoride which is an odorless gas.[12] Chloropicrin's mode of action is unknown[13] (IRAC MoA 8B).[14] Chloropicrin may stimulate weed germination, which can be useful when quickly followed by a more effective herbicide.[15]

Safety

At a national level, chloropicrin is regulated in the US by the United States Environmental Protection Agency as a restricted use pesticide.[9][16] Because of its toxicity and carcinogenicity, distribution and use of chloropicrin is available only to licensed professionals and specially certified growers who are trained in its proper and safe use.[9][16] In the US, occupational exposure limits have been set at 0.1 ppm over an eight-hour time-weighted average.[17]

Agriculture

In 2008 the US EPA re-approved chloropicrin as safe for use in agricultural settings, stating that treatments "can provide benefits to both food consumers and growers. For consumers, it means more fresh fruits and vegetables can be cheaply produced domestically year-round because several severe pest problems can be efficiently controlled."[18][19][20] To ensure chloropicrin is used safely, the EPA requires a strict set of protections for handlers, workers, and persons living and working in and around farmland during treatments.[9][19] EPA protections were increased in both 2011 and 2012, reducing fumigant exposures and significantly improving safety.[21] Protections include the training of certified applicators supervising pesticide application, the use of buffer zones, posting before and during pesticide application, fumigant management plans, and compliance assistance and assurance measures.[20][22]

Used as a preplant soil treatment measure, chloropicrin suppresses soilborne pathogenic fungi and some nematodes and insects. According to chloropicrin manufacturers, with a half-life of hours to days, it is completely digested by soil organisms before the crop is planted, making it safe and efficient. Contrary to popular belief, chloropicrin does not sterilize soil and does not deplete the ozone layer, as the compound is destroyed by sunlight. Additionally, chloropicrin has never been found in groundwater, due to its low solubility.[23]

California

In California experience with acute effects of chloropicrin when used as a soil fumigant for strawberries and other crops led to the release of regulations in January 2015 creating buffer zones and other precautions to minimize exposure of farm workers, neighbors, and passersby.[24][25]

High concentrations

Gas identification art for chloropicrin

Chloropicrin is harmful to humans. It can be absorbed systemically through inhalation, ingestion, and the skin. At high concentrations it is severely irritating to the lungs, eyes, and skin.[26] In World War I, German forces used concentrated chloropicrin against Allied forces as a tear gas. While not as lethal as other chemical weapons, it induced vomiting and forced Allied soldiers to remove their masks to vomit, exposing them to more toxic gases used as weapons during the war.[27] In 2024, Ukrainian armed forces claimed Russia was using chloropicrin in K-51 grenades.[28]

Damage to protective gear

Chloropicrin and its derivative phosgene oxime have been known to damage or compromise earlier generations of personal protective equipment. Some of the soldiers attacked mentioned a white smoke emerging from their gas masks.[citation needed]

See also

References

  1. ↑ 1.0 1.1 1.2 1.3 1.4 1.5 NIOSH Pocket Guide to Chemical Hazards. "#0132". National Institute for Occupational Safety and Health (NIOSH). https://www.cdc.gov/niosh/npg/npgd0132.html. 
  2. ↑ http://msds.chem.ox.ac.uk/CH/chloropicrin.html [|permanent dead link|dead link}}]
  3. ↑ 3.0 3.1 "Chloropicrin". Immediately Dangerous to Life and Health Concentrations (IDLH). National Institute for Occupational Safety and Health (NIOSH). https://www.cdc.gov/niosh/idlh/76062.html. 
  4. ↑ Foulkes, C.H. (31 Jan 2012). "GAS!" — The Story of the Special Brigade. Andrews UK Limited. p. 193. 
  5. ↑ "RED Fact Sheet: Chloropicrin". US Environmental Protection Agency. 10 July 2008. p. 2. http://www.epa.gov/oppsrrd1/REDs/factsheets/chloropicrin-fs.pdf. 
  6. ↑ Sheldon B. Markofsky "Nitro Compounds, Aliphatic" in Ullmann's Encyclopedia of Industrial Chemistry, Wiley-VCH, Weinheim, 2005.
  7. ↑ 7.0 7.1 7.2 7.3 7.4 7.5 "Executive Summary - Evaluation of Chloropicrin As A Toxic Air Contaminant". Department of Pesticide Regulation - California Environmental Protection Agency. February 2010. p. iv. http://www.cdpr.ca.gov/docs/emon/pubs/tac/exec_sum_0210.pdf. 
  8. ↑ Ayres, Leonard P. (1919). The War with Germany (Second ed.). Washington, DC: United States Government Printing Office. p. 80. https://archive.org/details/warwithgermanya02ayregoog. 
  9. ↑ 9.0 9.1 9.2 9.3 "Chloropicrin – Background". http://www.chloropicrinfacts.org/background.html. 
  10. ↑ 10.0 10.1 "Factsheet: Chloropicrin". http://www.workcover.nsw.gov.au/Documents/Publications/AlertsGuidesHazards/DangerousGoodsExplosivesFireworksPyrotechnics/chloropicrin_fact_sheet_1371.pdf. 
  11. ↑ Amos Alfred Fries; Clarence Jay West (1921). Chemical warfare. McGraw-Hill book company, inc.. p. 144. https://archive.org/details/chemicalwarfare00westgoog. 
  12. ↑ "Vikane® gas fumigant – Trusted by Homeowners, Preferred by Professionals". http://termitetenting.com/. 
  13. ↑ Chloropicrin in the Pesticide Properties DataBase (PPDB), University of Hertfordshire, accessed 2021-03-10.
  14. ↑ "IRAC Mode of Action Classification Scheme Version 9.4". March 2020. http://irac-online.org/documents/moa-classification/. 
  15. ↑ Martin, Frank N. (2003). "Development of Alternative Strategies for Management of Soilborne Pathogens Currently Controlled with Methyl Bromide". Annual Review of Phytopathology (Annual Reviews) 41 (1): 325–350. doi:10.1146/annurev.phyto.41.052002.095514. ISSN 0066-4286. PMID 14527332. 
  16. ↑ 16.0 16.1 "Chloropicrin Mitigation Proposal". Department of Pesticide Regulation – California Environmental Protection Agency. 15 May 2013. p. 1. http://www.cdpr.ca.gov/docs/whs/pdf/dpr_chloropicrin_mitigation_proposal_and_app_1-3.pdf. 
  17. ↑ "NIOSH Pocket Guide to Chemical Hazards". Centers for Disease Control and Prevention. https://www.cdc.gov/niosh/npg/npgd0132.html. 
  18. ↑ "Amended Reregistration Eligibility Decision (RED) for Chloropicrin". United States Environmental Protection Agency. May 2009. http://www.epa.gov/oppsrrd1/REDs/chloropicrin-red-amended.pdf. 
  19. ↑ 19.0 19.1 "Chloropicrin Mitigation Proposal". Department of Pesticide Regulation – California Environmental Protection Agency. 15 May 2013. p. 2. http://www.cdpr.ca.gov/docs/whs/pdf/dpr_chloropicrin_mitigation_proposal_and_app_1-3.pdf. 
  20. ↑ 20.0 20.1 "Environmental Protection Agency (EPA) Re-Registers Chloropicrin As Safe For Use Nationwide". http://www.chloropicrinfacts.org/safety.html. 
  21. ↑ "Chloropicrin Mitigation Proposal". Department of Pesticide Regulation – California Environmental Protection Agency. 15 May 2013. p. 2. http://www.cdpr.ca.gov/docs/whs/pdf/dpr_chloropicrin_mitigation_proposal_and_app_1-3.pdf. "The Amended RED incorporated final new safety measures to increase protections for agricultural workers and bystanders. These measures establish a baseline for safe use of the soil fumigants throughout the United States, reducing fumigant exposures and significantly improving safety." 
  22. ↑ "Chloropicrin – Frequently Asked Questions". http://www.chloropicrinfacts.org/faq.html. 
  23. ↑ "Chloropicrin Soil Fumigation in Potato Production Systems". Plant Management Network. American Phytopathological Society. https://www.plantmanagementnetwork.org/edcenter/seminars/potato/Chloropicrin/. 
  24. ↑ "Control Measures for Chloropicrin". California Department of Pesticide Regulation. January 6, 2015. http://www.cdpr.ca.gov/docs/whs/pdf/control_measures_chloropicrin_summary.pdf. "added controls for chloropicrin when it is used as a soil fumigant. The controls are intended to reduce risk from acute (short-term) exposures that might occur near fields fumigated with products containing chloropicrin." 
  25. ↑ "Chloropicrin Mitigation Proposal". Department of Pesticide Regulation – California Environmental Protection Agency. 15 May 2013. p. 2. http://www.cdpr.ca.gov/docs/whs/pdf/dpr_chloropicrin_mitigation_proposal_and_app_1-3.pdf. "The new measures appearing on soil fumigant Phase 2 labels include buffer zones and posting, emergency preparedness and response measures, training for certified applicators supervising applications, Fumigant Management Plans, and notice to State Lead Agencies who wish to be informed of applications in their states." 
  26. ↑ Chloropicrin (PS): Lung Damaging Agent. National Institute for Occupational Safety and Health. Emergency Response Safety and Health Database, August 22, 2008. Retrieved December 23, 2008.
  27. ↑ Heller, Charles E. (September 1984). "Chemical Warfare in World War I: The American Experience, 1917-1918". Leavenworth Papers (10): 23. https://www.armyupress.army.mil/Portals/7/combat-studies-institute/csi-books/leavenworth-papers-10-chemical-warfare-in-world-war-i-the-american-experience-1917-1918.pdf. 
  28. ↑ Russia Accused of Using WWI-Era Chemical Weapon in Ukraine, Newsweek Jan 31, 2024



Retrieved from "https://handwiki.org/wiki/index.php?title=Chemistry:Chloropicrin&oldid=3322305"